Lennie03

Jip and no return on elecrical parts is SA Sent from my SM-G920F using Tapatalk

Hi found the culprit at last. The new stator was bad so i had my old one rewound and it works 100% ever with the old R/R. The new stator didn't give enough amps thru to charge when the lights was onSent from my SM-G920F using Tapatalk

Hi Switchblade. I studied the wire diagram and stripped the harnass open. I found that the wire marked (E) coming out of the righthand fusebox (brouwn/Blue) somehow grounds somewhere even if everything is plugged out any advise?

Thanx Sent from my SM-G920F using Tapatalk

Thanx will do and report back Sent from my SM-G920F using Tapatalk

All vfr parts and no add-ons Sent from my SM-G920F using Tapatalk

Also new battery and standard lights Sent from my SM-G920F using Tapatalk

Ok everything is replaced but still no luck. Only when te lights are not coneccted does the battery charge Sent from my SM-G920F using Tapatalk

Ok thanx will do so

Back again and still struggling, when the low beam headlight relay is plugged out and my vfr idle's the voltage stays on 12.5 volts rev is up to 5000rpm it goes up to 13.2Volts. When the relay is plugged back in the charge goes away and the battery drains away. With the R/R unplugged the red wires test 19.8volts and plugged in without the headlight relay it goes down to12.5 volts. The stators disconected test 4.5V,11.4V and 19.5V is the stator faulty? It also gets hot when plugged in... (ps all the earth block are soldered so no bad earth connections) Please HELP

Hi all.Thanx for all the help. There is also a white earth connector block near the battery but runs next to the engine just before the wire's split to the tailights/battery and feul level plugs. after a long search i found that it also had made a bad connection witch lead to the battery not charging.